RX8--Transmission (Manual & Auto)

CLUTCH RELEASE COLLAR CLUTCH RELEASE COLLAR INSPECTION CAUTION: Do not clean the clutch release collar with cleaning fluids or ...

FLYWHEEL FLYWHEEL INSPECTION Remove the flywheel. NOTE: Correct slight scratches and discoloration using sandpaper. Inspect t ...

MANUAL TRANSMISSION [Y16M-D] TRANSMISSION/TRANSAXLE MANUAL TRANSMISSION LOCATION INDEX 1 Transmission oil 2 Oil seal (extension ...

TRANSMISSION/TRANSAXLE OIL TRANSMISSION OIL INSPECTION Position the vehicle on level ground. Remove oil filler plug. Verify tha ...

Tightening torque o 27 48 N·m {2.84.9 kgf·m, 2035 ft·lbf} Add the specified amount and type of oil through the plug port for ...

OIL SEAL (EXTENSION HOUSING) OIL SEAL (EXTENSION HOUSING) REPLACEMENT Drain the transmission oil. Remove the following parts: a ...

Perform the 'INSPECTION AFTER TRANSMISSION INSTALLATION', and verify that there is no malfunction. 1 Shift lever knob 2 Upper ...

3 Shift insulator component (outer) 4 Shift insulator component (inner) 5 Shift lever component 6 Front tunnel member 7 Rear tun ...

Remove the power plant frame. Propeller Shaft Removal Note Install the SST to the main shaft. Insert a slab of wood behind th ...

Remove the transmission installation bolt. Remove the transmission. Transmission Installation Note Shift to any gear position ...

Bolt length o A: 55 mm {2.1 in} o B: 90 mm {3.5 in} Tightening torque o 37 52 N·m {3.85.3 kgf·m, 2838 ft·lbf} Power Plant Fra ...

Standard dimension A o 48.456.4 mm {1.912.22 in} NOTE: When raising power plant frame without a transmission jack, use bolts ...

Tightening torque o 126.0154.0 N·m {12.915.7 kgf·m, 93.0113 ft·lbf} Verify again that dimension A is within the spe ...

TRANSMISSION/TRANSAXLE TRANSMISSION/TRANSAXLE TECHNICAL DATA Item Specifications CLUTCH Pedal free play (mm {in}) 5 15 {0.200. ...

Type ATF M-III or equivalent (e.g. Dexron® III) Capacity (Approx. quantity) ATF (L {US qt, lmp qt}) 8.7 {9.2, 7.7} Idle 320  45 ...

ATF temperature: 130 °C {266 °F} 0.0890.099 Turbine sensor (ohm) M range, 1st gear at 20 km/h {12 mph} 7 Vehicle speedometer se ...

AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION LOCATION INDEX 1 Automatic transmission fluid (ATF) (See AUTOMATIC TRANSMISSION FL ...

(See TURBINE SENSOR INSPECTION .) (See TURBINE SENSOR REMOVAL/INSTALLATION .) 5 Vehicle speed sensor (VSS) (See VEHICLE SPEED SE ...

MECHANICAL SYSTEM TEST Mechanical System Test Preparation Engage the parking brake and use wheel chocks at the front and rear o ...

Firmly depress the brake pedal with the left foot. Shift the selector lever to the D range. CAUTION: If the accelerator pedal ...